Recent content by jarredtipton

  1. J

    Hayabusa revival project

    Ok, I recoated the tank with por-15 and changed the fuel pump pre-screen. Engine problem is solved. It runs great. I'm still having a problem with the rear brake sticking. I have flushed the fluid and rebuilt the caliper. I'm going to try rebuilding the master cylinder. Its so bad the rear wheel...
  2. J

    Hayabusa revival project

    Well I took the tank off today, found out the problem, there is more rust again which I imagine clogged the prefilter. I'm going to go ahead and use por-15 tank sealer and replace the little $6 prefilter thing.
  3. J

    Hayabusa revival project

    Not that I know of, I think only 99-2000 busas had a fuel petcock that could be turned off
  4. J

    Hayabusa revival project

    Fuel line isnt kinked, what petcock?
  5. J

    Hayabusa revival project

    Update on this, I got the bike running great for a couple 100 miles. Now it will idle, and it will accelerate if I give it a very small amount of throttle, but if I give it any more than a quarter throttle it cuts out and bogs down. Does anyone know where to start? I did the fuel filter mod, so...
  6. J

    Hayabusa revival project

    I ordered a cush drive from you as well, Whats the average shipping time for your site?
  7. J

    Hayabusa revival project

    Thats the plan, already ordered a 17T. Hopefully it will help it be more street-able.
  8. J

    Hayabusa revival project

    Well I figured out why the speedo was far off and why I had so much wheel spin. Previous owner put a 15T front sprocket on.
  9. J

    Hayabusa revival project

    Also I really need to get new tires put on, I have them ordered. Went for a spin today and all I do in 1st and 2nd gear is spin with no more than half throttle.
  10. J

    Hayabusa revival project

    I guess previous owner changed the front sprocket. The rear is has 40t. I tested speed with GPS and at 90mph indicated I'm only doing about 72
  11. J

    Hayabusa revival project

    Got it running! Its runs good. It started right up after I changed the plugs, new battery, new(used) fuel pump, and cleaned the injectors. Previous owner must have put a different rear sprocket on it, the speedo is way off, or at least it seems like it. I'll have to check with the GPS on my...
  12. J

    Hayabusa revival project

    Is "flash rust" not a problem when using Evaporust?
  13. J

    Hayabusa revival project

    Whats everyone's favorite products for cleaning rust out of a tank and coating it?
  14. J

    Hayabusa revival project

    Thanks for the replies guys, I changed out the plugs. The new battery and fuel pump arrive in a couple days. Hopefully I'll get it started up without to many issues.
  15. J

    Hayabusa revival project

    Could it be caused by just starting the bike occasionally in the garage until over time it wouldn't start anymore? Thats what the previous owner said he had done. Whats would the possible fixes be?
Back
Top